ISONIC 2010 Vergrößern
Produktbeispiel
Benutzen sie das Scroll Rad an der Maus zur Größenänderung

ISONIC 2010

Ein Produkt vom Technologieführer für Phased Array und TOFD

 SONOTRON NDT :

PA Ultraschallgerät und Rekorder mit konventioneller UT und TOFD Technik; ISONIC 2010 EL-Starter Paket PA16:16 + 1Kanal UT/TOFD; ISONIC 2010 PA32/32 + 1oder2 Kanal UT/TOFD; ISONIC 2010 DUET PA 2x16:16/1x 32:32 + 1oder2 Kanal UT/TOFD;  
Ein Gerät mit TTGI Technik!

Mehr Infos

0 sofort lieferbar

Preis auf Anfrage!!!

Auf meine Wunschliste

ISONIC 10 Phased Array UT und TOFD Ultraschallgerät & Rekorder

  • Phased Array, TOFD und konventionelle Technik in einem Gerät
  • Einzigartige ortsgetreue Reflektordarstellung in der Abbildung des Prüfkörpers

 

  • 32:32 Phased Array Elektronik bzw. 16:16 Elektronik für EL Version bzw. 2x 16:16 + 1 x 32:32 Elektronik
  • Ortsgetreue Abbildung (true to geometry), B-Scan, S-Scan, C-Scan A-Bild
  • Ortsgetreue 3D Darstellung in den Abmessungen des Prüfkörpers
  • DAC, TCG
  • 100% Rohdatensicherung
  • Simultane Delaminationsprüfung und Koppelkontrolle während der Schweißnahtprüfung
  • Viele Software Optionen für ortsgetreue Reflektordarstellung verschiedener Schweißnahttypen und andere Körper

 

UT und TOFD 

  • 1 oder 2 Kanal für konventionelle Prüfung und TOFD
  • Impulsecho / SE Modus
  • A-, B-, CB-Scan
  • TOFD, DAC, AVG, TCG

Technical Data

Phased Array

Organization: 1 X 32:32 or 2 X 16:16
Pulse Type: Bipolar Square Wave
Initial Transition: <=7.5 ns (10-90% for rising edges / 90-10% for falling edges)
Pulse Amplitude: Smoothly tunable (12 levels) 50V … 300 Vpp into 50 Ohms
Half Wave Pulse Duration: 50…600 ns controllable in 10 ns step
Probe Types: Linear / Ring Array
Emitting aperture: 1..32
Phasing (emitting aperture): 0…100 us with 5 ns resolution
Receiving Aperture: 1..32
Gain: 0...100 dB controllable in 0.5 dB resolution
Advanced Low Noise Design: 85 uV peak to peak input referred to 80 dB gain / 25 MHz bandwidth
Frequency Band: 0.2 … 25 MHz Wide Band
A/D Conversion: 100 MHz 16 bit
Superimposing of receiving aperture signals: On-the-fly, no multiplexing involved
Phasing (receiving aperture): On-the-fly 0…100 us with 5 ns resolution
A-Scan Display Modes: RF, Rectified (Full Wave / Negative or Positive Half Wave)
DAC / TCG per focal law - for rectified and RF display: Theoretical – dB/mm (dB/")
Experimental – through sequential recording echo amplitudes from variously distanced equal reflectors
46 dB Dynamic Range, Slope <= 20 dB/us, Capacity <= 40 points
Gates per focal law: 2 Independent Gates / unlimitedly expandable
Gate Start and Width: Controllable over whole variety of A-Scan Display Delay and A-Scan Range 
in 0.1 mm /// 0.001" resolution
Gate Threshold: 5…95 % of A-Scan height controllable in 1 % resolution
Number of focal laws: 8192
Scanning and Imaging modes: B-Scan (E-Scan) - regular and True-To-Geometry
Sector Scan (S-Scan) - regular and True-To-Geometry
One-probe multi-group image composed from several B- and S-Scans
Top (C-Scan), Side, End View imaging formed through encoded / time-based line scanning, 3D-Viewer
Method of data storage: 100% raw data capturing


Conventional UT and TOFD

Number of Channels: 1 or 2
Pulse Type: Bipolar Square Wave with electronically controlled damping
Initial Transition: <=7.5 ns (10-90% for rising edges / 90-10% for falling edges)
Pulse Amplitude: Smoothly tunable (12 levels) 50V … 400 Vpp into 50 Ohms
Half Wave Pulse Duration: 50…600 ns independently controllable in 10 ns step
Modes: Single / Dual
Gain: 0...100 dB controllable in 0.5 dB resolution
Advanced Low Noise Design: 85 uV peak to peak input referred to 80 dB gain / 25 MHz bandwidth
Frequency Band: 0.2 … 25 MHz Wide Band
A/D Conversion: 100 MHz 16 bit
Digital Filter: 32-Taps FIR band pass with controllable lower and upper frequency limits
A-Scan Display Modes: RF, Rectified (Full Wave / Negative or Positive Half Wave), Signal's Spectrum (FFT Graph)
DAC / TCG - for rectified and RF display: Theoretical – dB/mm (dB/")
Experimental – through sequential recording echo amplitudes from variously distanced equal reflectors
46 dB Dynamic Range, Slope ? 20 dB/us, Capacity <= 40 points
DGS: Standard Library for 18 probes / unlimitedly expandable
Gates: 2 Independent Gates / unlimitedly expandable
Gate Start and Width: Controllable over whole variety of A-Scan Display Delay and A-Scan Range in 0.1 mm /// 0.001" resolution
Gate Threshold: 5…95 % of A-Scan height controllable in 1 % resolution
Measuring Functions – Digital
Display Readout:
27 automatic functions / expandable; Dual Ultrasound Velocity Measurement Mode for Multi-Layer Structures; Curved Surface / Thickness / Skip correction for angle beam probes; Ultrasound velocity and Probe Delay Auto-Calibration for all types of probes
Freeze (A-Scans and Spectrum Graphs): Freeze All – A-Scans and Spectrum Graphs / Freeze Peak – A-Scans / All measurements functions, manipulating Gates, and ±6dB Gain varying are available for frozen signals
Scanning and Imaging: Single Channel: Thickness Profile B-Scan, Cross-sectional B-Scan, Plane View CB-Scan, TOFD
Dual Channel: Strip Charts of 4 types (Amplitude/TOF PE, Map, TOFD, Coupling)
Standard Length of one Line Scanning record: 50…20000 mm (2"…800"), automatic scrolling
Method of data storage: 100% raw data capturing


General

PRF: 10...5000 Hz controllable in 1 Hz resolution
On-Board Computer CPU: AMD LX 800 - 500MHz
RAM: 1 Gygabyte
Screen: Sun readable 8.5” touch screen 800 x 600
Controls: Sealed keyboard and mouse
Interface: 2 x USB, Ethernet
Operating System: Windows™ XP Embedded
Encoder interface: Incremental TTL encoder
Standard Length of one Line Scanning record: 50…20000 mm (2"…800"), automatic scrolling
Housing: IP 53 rugged aluminum case with carrying handle
Dimensions: 265x156x101 mm (10.43"x6.14"x3.98") - without battery
265x156x139 mm (10.43"x6.14"x5.47") - with battery
Weight: 2.500 kg (5.50 lbs) – without battery
3.430 kg (7.55 lbs) – with battery

Post processing software for Phased array video 1 of 2  

Post processing software for Phased array video 2 of 2  

PA software update 

7 andere Artikel in der gleichen Kategorie: